Gold Science and Technology
img

Wechat

Adv. Search
Online Submission Peer Review Office Work

Gold Science and Technology ›› 2022, Vol. 30 ›› Issue (4): 612-622.doi: 10.11872/j.issn.1005-2518.2022.04.025

• Mining Technology and Mine Management • Previous Articles     Next Articles

Numerical Simulation of Dynamic Response of Tunnel Lining Under Oil Tank Explosion

Zhanxing ZHOU(),Kewei LIU(),Xudong LI,Xiaohui HUANG,Sizhou MA   

  1. School of Resources and Safety Engineering，Central South University，Changsha 410083，Hunan，China
  • Received:2022-01-21 Revised:2022-05-16 Online:2022-08-31 Published:2022-10-31
  • Contact: Kewei LIU E-mail:zzx1230@csu.edu.cn;kewei_liu@126.com

RichHTML

0

PDF (PC)

372

Abstract:

The dynamic response of underground engineering such as tunnel and mining roadway under the action of the explosion load of oil and gas is an important basis for engineering protection design and safety evaluation.The development of dynamic numerical simulation method in line with the characteristics of oil and gas explosion is of great significance for accurately analyzing the stability of underground engineering structures such as tunnel and mining roadway under liquefied petroleum gas （LPG） explosion. In this paper，fluid computational mechanics software FLACS was used to calculate the LPG explosion load in the tunnel. Based on transient dynamic analysis software LS-DYNA，the blast impact load was applied to the tunnel lining surface，and then the dynamic response of lining structure at different distances from the explosion center was calculated.By comparing the peak value of overpressure obtained by simulation with the calculation results of the empirical formula，the coincidence between the peak value of overpressure obtained by simulation and the calculation results of the empirical formula is high，which shows that the simulation method used in this paper has good applicability for analyzing the structural response of tunnel under LPG explosion in tunnel.Based on the numerical simulation results，the variation laws of stress，displacement and velocity of lining structure under LPG explosion load were studied.The results show that the “angular structure” of the tunnel has a strengthening effect on the reflection of shock wave，resulting in the formation of stress concentration at the corresponding position and the slow attenuation of the stress wave intensity.With the increase of the propagation distance，the stress on the lining decreases gradually and the stress value of the same section tends to be consistent.In addition，the velocity and displacement values at different measuring points on the same section are affected by the distance between measuring point and explosion center and the geometric structure of the tunnel.When the distance between measuring point and explosion center is larger than 12 m，the velocity and displacement values tend to be stable.The damage of top lining and bottom structure is more likely to occur under the action of blast load，and the damage degree of sidewall position is less.The research results provide a method basis for the safety and stability analysis of underground structures，and also have a certain reference value for the anti-explosion design of mining roadway structure and the corresponding support optimization in mining.

Key words: tunnel lining, liquefied petroleum gas （LPG）, oil tank explosion, numerical simulation, dynamic response

CLC Number: 

  • TE834

Fig.1

Explosion loading-time history curve"

Fig.2

Calculation and loading of explosion load"

Fig.3

Dimensions of tunnel cross section"

Fig.4

Model of numerical calculation"

Fig.5

Division of subareas and distribution of measurement points"

Fig.6

Equation curve of state of the H-J-C model"

Table 1

Calculation parameters of H-J-C model"

参数含义取值参数含义取值参数含义取值
ρ0/（kg?m-3）密度2 440μc体积应变0.001G/GPa剪切模量14.86
fc/MPa单轴抗压强度48K1/GPa压力常数85D1损伤常数0.04
A黏性强度系数0.79K2/GPa压力常数-171D2损伤常数1.0
B压力硬化系数1.6K3/GPa压力常数208EFMIN最小塑形应变0.01
N压力硬化指数0.61pl/GPa锁定压力0.8T/MPa单轴抗拉强度4
C应变率系数0.007μl锁定体积应变0.100ε参考应变率1e-6
Pc/MPa静水压力16SMAX最大等效应力7.0fs失效参数0.004

Fig.7

Comparison between numerical simulation results and empirical formula calculation results"

Fig.8

Transverse propagation characteristics of stress wave"

Fig.9

Longitudinal propagation characteristics of stress wave"

Fig.10

Schematic diagram of measurement points on the tunnel lining"

Fig.11

Displacement response curves of lining structure"

Fig.12

Velocity response curves of lining structure"

Berg A， Voort M， Weerheijm J，et al，2004.Expansion-controlled evaporation：A safe approach to BLEVE blast［J］.Journal of Loss Prevention in the Process Industries，17（6）：397-405.
Berg A， Voort M， Weerheijm J，et al，2006.BLEVE blast by expansion-controlled evaporation［J］.Process Safety Progre-ss，25（1）：44-51.
Birk A M， Davison C， Cunningham M，2007.Blast overpressures from medium scale BLEVE tests［J］.Journal of Loss Prevention in the Process Industries，20（3）：194-206.
CCPS，2011.Guidelines for vapor cloud explosion，pressure vessel burst，BLEVE，and flash fire hazards［J］.Process Safety Progress，30（2）：187.
Chen Lei， Ye Qing，2021.Numerical simulation of the effect of gas explosion on tunnel lining stress［J］.Mining Engineering Research，36（3）：40-47.
Deng Zhaoyu，2020.Numerical simulation study on damage and failure of roadway wall caused by gas explosion［J］.Science Technology and Engineering，20（5）：1792-1798.
Ding Yuqi， Ye Bitao， Lu Ye，et al，2021.Implosion load calculation and structural failure analysis of storage tank based on different equivalent methods［J］.Chemical Machinery，48（1）：35-43.
Guo Y B， Liu C C， Wang D G，et al，2018.Numerical study and safety spacing of buried parallel gas pipelines：A study based on TNT equivalent method［J］.International Journal of Pressure Vessels and Piping，168：246-257.
Hao H， Hao Y F， Li J，et al，2016.Review of the current practices in blast-resistant analysis and design of concrete structures［J］.Advances in Structural Engineering，19（8）：1193-1223.
Holmquist T J， Johnson G R， Cook W H，1993.A computational constitutive model for concrete subjected to large strains，high strain rates and high pressures［C］// Proceeding of 14th International Symposium on Ballistics.Quebec：BIC： 591-600.
Lai H P， Wang S Y， Xie Y L，2016.Study on the fire damage characteristics of the new Qidaoliang highway tunnel：Field investigation with computational fluid dynamics（CFD）back analysis［J］.International Journal of Environmental Research and Public Health，13（10）：1014.
Li J D， Hao H，2020.Numerical study of medium to large scale BLEVE for blast wave prediction［J］.Journal of Loss Prevention in the Process Industries，65：104107.
Li J D， Hao H，2021.Numerical simulation of medium to large scale BLEVE and the prediction of BLEVE’s blast wave in obstructed environment［J］.Process Safety and Environmental Protection，145：94-109.
Li Z P， Wu S C， Cheng Z Q，et al，2018.Numerical investigation of the dynamic responses and damage of linings subjected to violent gas explosions inside highway tunnels［J］.Shock and Vibration，（9）：2792043.1-2792043.20.
Li Z， Chen L， Fang Q，et al，2019.Experimental and numerical study on CFRP strip strengthened clay brick masonry walls subjected to vented gas explosions［J］.International Journal of Impact Engineering，129（1）：66-79.
Li Zhipeng， Wu Shunchuan，2018.Damage mechanism of tunnel entrance caused by violent gas explosion［J］.Journal of Engineering Science，40（12）：1476-1487.
Liu K W， Li X D， Hao H，et al，2019.Study on the raising technique using one blast based on the combination of long-hole presplitting and vertical crater retreat multiple-deck shots［J］.International Journal of Rock Mechanics and Mining Sciences，113：41-58.
Liu K W， Yang J C， Li X B，et al，2018.Study on the long-hole raising technique using one blast based on vertical crater retreat multiple deck shots［J］.International Journal of Rock Mechanics and Mining Sciences，109：52-67.
Liu Weiwei， Cheng Kai， Ren Hongxia，2019.Numerical simulation of tunnel gasoline explosion based on FLACS［J］.Journal of Beihua University（Natural Science Edition），20（3）：395-401.
Liu Yang， Li Zhan， Zhang Yadong，et al，2021.Safety assessment of gas cloud explosion in a city gas storage and distribution station based on FLACS［J］.Chinese Journal of High Pressure Physics，35（1）：117-131.
LS-DYNA，2013.Keyword User’s Manual［M］.Version 971.Livermore，CA：Livermore Software Technology Corporation（LSTC）.
Masellis M，2000.Fire disaster in a motorway tunnel［J］.Prehospital Disaster Medicine，15（Supp.2）：S74.
Molenaar D J， Weerheijm J， Vervuurt A，et al，2009.Bijzondere belastingen in tunnels：Eindrapport［J］.Delft Cluster，TC 211-05-09.
Peng Pei， Li Zhan， Zhang Yadong，et al，2020.Performance of retrofitted autoclaved aerated concrete masonry walls subjected to gas explosions［J］.Explosion and Shock Waves，40（3）：107-120.
Pennetier O， William-Louis M， Langlet A，2015.Numerical and reduced-scale experimental investigation of blast wave shape in underground transportation infrastructure［J］.Process Safety and Environmental Protection，94：96-104.
Vervuurt A H J M， Galanti F M B， Wubsi A J，et al，2007.Effect of explosions in tunnels-Preliminary assessment of the structural response［J］.Delft Cluster，2007-DR0156/A.
Wang Haiyang， Zhao Shulei， Chen Xiang，et al，2021.Statistics and influencing factors analysis of tunnel gas accidents in China［J］.China Safety Science Journal，31（4）：34-40.
Wang S P， Li Z， Fang Q，et al，2021.Performance of utility tunnels under gas explosion loads［J］.Tunnelling and Underground Space Technology，109：103762.
Yang Kezhi， Yang Xiumin，2003.Shock waves propagation insi-de tunnels［J］.Explosion and Shock Waves，23（1）：37-40.
陈雷，叶青，2021.瓦斯爆炸对隧道衬砌应力影响的数值模拟［J］.矿业工程研究，36（3）：40-47.
邓照玉，2020.瓦斯爆炸对巷道壁面损伤破坏的数值模拟研究［J］.科学技术与工程，20（5）：1792-1798.
丁宇奇，叶碧涛，芦烨，等，2021.基于不同等效方法的储罐内爆载荷计算与结构破坏分析［J］.化工机械，48（1）：35-43.
李志鹏，吴顺川，2018.剧烈瓦斯爆炸隧道洞口致损机理［J］.工程科学学报，40（12）：1476-1487.
刘维维，成凯，任红霞，2019.基于FLACS的隧道汽油爆炸数值模拟［J］.北华大学学报（自然科学版），20（3）：395-401.
刘洋，李展，张亚栋，等，2021.基于FLACS的某城市燃气储配站气云爆炸安全评估［J］.高压物理学报，35（1）：117-131.
彭培，李展，张亚栋，等，2020.燃气爆炸作用下蒸压加气混凝土砌体墙的加固性能［J］.爆炸与冲击，40（3）：107-120.
王海洋，赵树磊，陈祥，等，2021.我国瓦斯爆炸事故统计及影响因素分析［J］.中国安全科学学报，31（4）：34-40.
杨科之，杨秀敏，2003.坑道内化爆冲击波的传播规律［J］.爆炸与冲击，23（1）：37-40.
[1] Xiangrui HE, Xianyang QIU, Xiuzhi SHI, Xiaoyuan LI, Wei ZHI, Jun LIU, Yuanlai WANG. Study on the Movement Law of Overlying Strata in Underground Mining with Nonlinear Elastic Foundation Beam [J]. Gold Science and Technology, 2024, 32(4): 640-653.
[2] Yunlin YU, Kepeng HOU, Bajiu YANG, Yong CHENG, Taihong LU, Nannan ZHANG. Study on Pillar Mining Scheme of Gaofengshan Ore Section in Yunxi [J]. Gold Science and Technology, 2024, 32(3): 445-457.
[3] Bo LI, Chen WEN, Xiuzhi SHI. Optimization of Stope Sidewall Controlled Blasting Parameters for High-Stress Fan-Shaped Medium-Depth Hole [J]. Gold Science and Technology, 2024, 32(3): 511-522.
[4] Kuan LIU, Guanwang MO, Xiang LI, Pinghuan SHEN, Bo WAN, Jiankun LIU. Optimization of the Construction Parameters of Super-large Section Flat Structure Tunnel [J]. Gold Science and Technology, 2024, 32(2): 330-344.
[5] Kaibin WANG, Qin LIU, Hongtao WANG. Study on the Load Transfer Characteristics and Influence Factors of Anchora-ge Segment of Pressure-type Anchor Cable [J]. Gold Science and Technology, 2024, 32(1): 123-131.
[6] Zefeng XU, Xiuzhi SHI, Rendong HUANG, Wenzhi DING, Xin CHEN. Study on Filling Pipeline Optimization Based on Full Pipe Transportation [J]. Gold Science and Technology, 2024, 32(1): 160-169.
[7] Jielin LI, Yiliang LIU, Yupu WANG, Zaili LI, Keping ZHOU, Chunlong CHENG. Influence of Forced-Exhaust Mixed Ventilation Parameters on the Cooling Effect of Artificial Cooling in High-temperature Blind Roadway [J]. Gold Science and Technology, 2024, 32(1): 63-74.
[8] Honglu FEI, Hainan JI, Jie SHAN. Optimization and Comparative Experimental Study of Charge Structure of Water Medium Interval on Open-air Step [J]. Gold Science and Technology, 2023, 31(6): 930-943.
[9] Wenfa SHAN, Xiancheng MAO, Zhankun LIU, Hao DENG, Jin CHEN, Wei ZHANG, Haizheng WANG, Xin YANG. Numerical Simulation of Metallogenic Processes of Dayingezhuang Gold Deposit in Jiaodong Peninsula and Its Prospecting Significance [J]. Gold Science and Technology, 2023, 31(5): 707-720.
[10] Yu ZHANG, Wenji WANG, Jiaqi SUN, Yonggang XIAO. Fracture Performances of Bedding Structure Slate Under Dynamic Loading [J]. Gold Science and Technology, 2023, 31(5): 803-810.
[11] Yanan ZHAO, Yihang ZHAO, Zhongming JIANG, Hongmin ZHAO. Preliminary Study on Static and Dynamic Stability of Canister for High-level Radioactive Nuclear Waste Disposal Based on Discrete Element Method [J]. Gold Science and Technology, 2023, 31(4): 592-604.
[12] Heng MA,Jiayi GAO,Shihu LI,Ke GAO. Influence of Jet Angle of Twin Parallel Air Curtains on the Tunnel Airflow [J]. Gold Science and Technology, 2022, 30(5): 743-752.
[13] Duiming GUO,Guoqing LI,Jie HOU,Nailian HU. Optimization of Local Ventilation Parameters of Deep Mine Excavation Roadway Based on FLUENT [J]. Gold Science and Technology, 2022, 30(5): 753-763.
[14] Lingzhi ZHONG,Xiancheng MAO,Zhankun LIU,Keyan XIAO,Chuntan WANG,Wu CHEN. Ore-controlling Effect of Structural Geometry Features in the Sanshandao Gold Belt，Jiaodong Peninsula，China： Insights from Numerical Simulation [J]. Gold Science and Technology, 2022, 30(3): 352-365.
[15] Weihua WANG,Yang LIU,Liwei ZHANG,Henggen ZHANG. Numerical Simulation of Homogeneous Rock Mass Damage Caused by Two-hole Simultaneous Blasting Based on RHT Model [J]. Gold Science and Technology, 2022, 30(3): 414-426.
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
No Suggested Reading articles found!

©2018 Gold Science and Technology　

Telephone：0931-8277791　

E-mail: hjkx@lzb.ac.cn Postcode：730000　

Powered by Beijing Magtech Co. Ltd

陇ICP备17001318号-1